Apply Now Clicking "Apply Now" opens the link in a new window.

How to Apply

A cover letter is required for consideration for this position and should be attached as the first page of your resume. The cover letter should address your specific interest in the position and outline skills and experience that directly relate to this position.

Responsibilities*

  • Conduct complex preventative and corrective maintenance and inspections of boiler systems.
  • Perform brazing and soldering.
  • Install and replace stainless steel and copper tubing, valves and component parts in equipment and electronic boiler control systems.
  • Fabricate and install parts by machining or cutting metal and bending steel pipe and sheet metal for duct work and stacks.
  • Repair or replace electrical motors, pumps, air compressors, heat exchangers, valves, bearings and pulleys on boiler related systems.
  • Install furnaces.
  • Calibrate and adjust natural gas pressure regulators.
  • Trim boiler combustion using flue gas analyzers on non-parallel positioning combustion control boilers.
  • Utilize mechanical and electrical blueprints for trouble shooting.
  • Layout and build boiler small bore pipe and tubing systems.
  • Rebuild, setup and calculate capacity of water softeners.
  • Observe University fire and safety procedures such as burn permits, personal protective equipment use, lockout and confined space procedures.
  • May coordinate the work, and instruct Boiler Operator Trainees and Boiler Operators.
  • Start up and shut down boilers, monitor boiler operations and react to varying load requirements.
  • Inspect and adjust automatic and manual boiler control mechanisms.
  • Clean, inspect and perform routine maintenance on equipment and facilities including but not limited to, oiling, greasing, repair of furnace refractories and repacking of leaking packing glands, inspecting, adjusting and replacing belts and rebuilding bottom blow valves.
  • Maintain chemical balance in boiler water according to prescribed procedures.

Required Qualifications*

  • Graduation from high school or a trade school, or an equivalent combination of education and experience.
  • Reasonable progressively responsible experience in boiler maintenance.
  • Considerable maritime or power house experience with high pressure boiler operations.
  • Demonstrate a detailed understanding and practical experience of the technologies associated with operating conventional and modern boiler controls.
  • Thorough knowledge of the equipment, methods and material used in boiler operations, water treatment, and combustion controls.
  • Considerable working knowledge and basic trouble shooting skills for all water treatment equipment such as reverse osmosis, water softeners, de-aerating feed tanks, etc.
  • Thorough knowledge of the operating and maintenance requirements of high and low pressure boilers and related equipment.
  • Advanced knowledge of boiler codes and their application.
  • Considerable mechanical aptitude.
  • Considerable knowledge of the equipment, methods and materials used in boiler operations.
  • Considerable knowledge of the operation and maintenance requirements of high pressure boiler and related equipment.
  • Ability to regulate boiler operations.
  • Must be able to perform the full range of duties, with or without a reasonable accommodation, in the classification in an environment that has high levels of heat and noise.

Additional Information

Facilities and Operations seeks to recruit and retain a diverse workforce as a reflection of our commitment to serve the diverse people of Michigan, to sustain the excellence of the university, and to offer our students richly varied disciplines, perspectives and ways of knowing and learning.

Union Affiliation

This position is covered under the collective bargaining agreement between the U-M and the International Union of Operating Engineers, which contains and settles all matters with respect to wages, benefits, hours and other terms and conditions of employment.

Background Screening

The University of Michigan conducts background checks on all job candidates upon acceptance of a contingent offer and may use a third party administrator to conduct background checks. Background checks will be performed in compliance with the Fair Credit Reporting Act.

U-M EEO/AA Statement

The University of Michigan is an equal opportunity/affirmative action employer.